Hydrogen, Fuel Cell & Energy Storage

Hydrogen, Fuel Cell & Energy Storage

Preparation of Nitrogen-Doped Graphene By Solvothermal Process as Supporting Material for Fuel Cell Catalysts

Document Type : Research Paper

Authors
Hosna Ghanbarlou 1
Soosan Rowshanzamir 2
Mohammad Javad Parnian 1
Bagher Kazeminasab 3
1 School of Chemical Engineering, Iran University of Science and Technology
2 Green Research Center (GRC) & School of Chemical Engineering (SChE) Iran University of Science & Technology
3 Department of energy engineering, Science and Research Branch, Islamic Azad University, Tehran.
10.22104/ijhfc.2014.57
Abstract
Development of efficient electrocatalysts for oxygen reduction reaction (ORR) is one of the most important issues for optimizing the performance of fuel cells and metal-air batteries. The introduction of nitrogen into carbon nanostructures has created new pathways for the development of non-precious electrocatalysts in fuel cells. In this work, nitrogen-doped graphene (NG) was synthesized by a low temperature solvothermal process to use as catalyst supports for oxygen reduction reactions (ORR). The morphology of the NG was studied using scanning electron microscopy, transmission electron microscopy and X-ray photoelectron spectroscopy. X-ray photoelectron spectroscopy showed that graphitic (Quaternary), pyridinic and pyridinic oxidized nitrogen formed by designed reaction and these types of nitrogen configurations has been found to be responsible for the ORR catalytic activity of N-doped carbon material. Cyclic voltammetry and linear sweep voltammetry were used to measure electrocatalytic activity. Electrochemical characterization reveal that the produced NG not only as support but also as catalyst has good catalytic activity for oxygen reduction reaction in alkaline media.
Keywords
nitrogen-doped graphene
solvothermal synthesis
Oxygen reduction reaction
fuel cell
Subjects
1. Bing Y, Liu H, Zhang L, Ghosh D, Zhang J. "Nanostructured Pt-alloy electrocatalysts for PEM fuel cell oxygen reduction reaction". Chem. Soc. Rev., 2010, 39: 2184.
2. Serov A, Kwak C. "Direct hydrazine fuel cells: A review". Applied Catalysis B: Environmental, 2010, 98: 1.
3. Zhang S, Shao Y, Yin G, Lin Y. "Stabilization of platinum nanoparticle electrocatalysts for oxygen reduction using poly(diallyldimethylammonium chloride)". J. Mater. Chem., 2009, 19: 7995.
4. Shao Y, Yin G, Gao Y. "Understanding and approaches for the durability issues of Pt-based catalysts for PEM fuel cell". J. Power Sources, 2007, 171: 558.
5. Wu H, Wexler D, Liu H. "Pt–Ni/C catalysts using different carbon supports for the cathode of the proton exchange membrane fuel cell (PEMFC)". Mater. Chem. Phys., 2012, 136: 845.
6. Chen Z, Higgins D, Yu A, Zhang L, Zhang J. "A review on non-precious metal electrocatalysts for PEM fuel cells". Energy & Environmental Science, 2011, 4: 3167.
7. Shao Y, Sui J, Yin G, Gao Y. "Nitrogen-doped carbon nanostructures and their composites as catalytic materials for proton exchange membrane fuel cell". Applied Catalysis B: Environmental, 2008, 79: 89.
8. Shanmugam S, Osaka T. "Efficient electrocatalytic oxygen reduction over metal free-nitrogen doped carbon nanocapsules". Chem. Commun., 2011, 47: 4463.
9. Mo Z, Liao S, Zheng Y, Fu Z. "Preparation of nitrogen-doped carbon nanotube arrays and their catalysis towards cathodic oxygen reduction in acidic and alkaline media". Carbon, 2012, 50: 2620.
10. Shen W, Fan W. "Nitrogen-containing porous carbons: synthesis and application". Journal of Materials Chemistry A, 2013, 1: 999.
11. Lin Z, Waller G H, Liu Y, Liu M, Wong C-p. "Simple preparation of nanoporous few-layer nitrogen-doped graphene for use as an efficient electrocatalyst for oxygen reduction and oxygen evolution reactions". Carbon, 2013, 53: 130.
12. Wu J, Zhang D, Wang Y, Hou B. "Electrocatalytic activity of nitrogen-doped graphene synthesized via a one-pot hydrothermal process towards oxygen reduction reaction". J. Power Sources, 2013, 227: 185.
13. Li H, Liu H, Jong Z, Qu W, Geng D, Sun X, Wang H. "Nitrogen-doped carbon nanotubes with high activity for oxygen reduction in alkaline media". Int. J. Hydrogen Energy, 2011, 36: 2258.
14. He C, Li Z, Cai M, Cai M, Wang J-Q, Tian Z, Zhang X, Shen P K. "A strategy for mass production of self-assembled nitrogen-doped graphene as catalytic materials". Journal of Materials Chemistry A, 2013, 1: 1401.
15. Geng D, Chen Y, Chen Y, Li Y, Li R, Sun X, Ye S, Knights S. "High oxygen-reduction activity and durability of nitrogen-doped graphene". Energy & Environmental Science, 2011, 4: 760.
16. Zahoor A, Christy M, Hwang Y J, Lim Y R, Kim P, Nahm K S. "Improved electrocatalytic activity of carbon materials by nitrogen doping". Applied Catalysis B: Environmental, 2014, 147: 633.
17. Lu Z-J, Bao S-J, Gou Y-T, Cai C-J, Ji C-C, Xu M-W, Song J, Wang R. "Nitrogen-doped reduced-graphene oxide as an efficient metal-free electrocatalyst for oxygen reduction in fuel cells". RSC Advances, 2013, 3: 3990.
18. Huang C, Li C, Shi G. "Graphene based catalysts". Energy & Environmental Science, 2012, 5: 8848.
19. Zhang L-S, Liang X-Q, Song W-G, Wu Z-Y. "Identification of the nitrogen species on N-doped graphene layers and Pt/NG composite catalyst for direct methanol fuel cell". PCCP, 2010, 12: 12055.
20. Xiong B, Zhou Y, Zhao Y, Wang J, Chen X, O’Hayre R, Shao Z. "The use of nitrogen-doped graphene supporting Pt nanoparticles as a catalyst for methanol electrocatalytic oxidation". Carbon, 2013, 52: 181.
21. Imran Jafri R, Rajalakshmi N, Ramaprabhu S. "Nitrogen doped graphene nanoplatelets as catalyst support for oxygen reduction reaction in proton exchange membrane fuel cell". J. Mater. Chem., 2010, 20: 7114.
22. Wang H, Maiyalagan T, Wang X. "Review on Recent Progress in Nitrogen-Doped Graphene: Synthesis, Characterization, and Its Potential Applications". ACS Catalysis, 2012, 2: 781.
23. Liu G, Li X, Lee J-W, Popov B N. "A review of the development of nitrogen-modified carbon-based catalysts for oxygen reduction at USC". Catalysis Science & Technology, 2011, 1: 207.
24. Liu Q, Zhang H, Zhong H, Zhang S, Chen S. "N-doped graphene/carbon composite as non-precious metal electrocatalyst for oxygen reduction reaction". Electrochim. Acta, 2012, 81: 313.
25. Subramanian N P, Li X, Nallathambi V, Kumaraguru S P, Colon-Mercado H, Wu G, Lee J-W, Popov B N. "Nitrogen-modified carbon-based catalysts for oxygen reduction reaction in polymer electrolyte membrane fuel cells". J. Power Sources, 2009, 188: 38.
26. Zhang M, Dai L. "Carbon nanomaterials as metal-free catalysts in next generation fuel cells". Nano Energy, 2012, 1: 514.
27. Lin Z, Song M-k, Ding Y, Liu Y, Liu M, Wong C-p. "Facile preparation of nitrogen-doped graphene as a metal-free catalyst for oxygen reduction reaction". PCCP, 2012, 14: 3381.
28. Deng D, Pan X, Yu L, Cui Y, Jiang Y, Qi J, Li W-X, Fu Q, Ma X, Xue Q, Sun G, Bao X. "Toward N-Doped Graphene via Solvothermal Synthesis". Chem. Mater., 2011, 23: 1188.
29. Geng D, Hu Y, Li Y, Li R, Sun X. "One-pot solvothermal synthesis of doped graphene with the designed nitrogen type used as a Pt support for fuel cells". Electrochem. Commun., 2012, 22: 65.
30. Bai J, Zhu Q, Lv Z, Dong H, Yu J, Dong L. "Nitrogen-doped graphene as catalysts and catalyst supports for oxygen reduction in both acidic and alkaline solutions". Int. J. Hydrogen Energy, 2013, 38: 1413.
31. Zheng B, Wang J, Wang F-B, Xia X-H. "Synthesis of nitrogen doped graphene with high electrocatalytic activity toward oxygen reduction reaction". Electrochem. Commun., 2013, 28: 24.
 
Hydrogen, Fuel Cell & Energy Storage
Volume 1, Issue 2 - Serial Number 2
Spring 2014
Pages 113-119