Numerical investigation of methanol crossover through the membrane in a direct methanol fuel cell

Document Type : Research Paper

Authors

1 Department of Chemical Engineering, Faculty of Engineering, University of Sistan and Baluchestan, Zahedan, Iran

2 Department of Mechanical Engineering, Dokuz Eylul University, Buca, Izmir, 35397, Turkey

Abstract

A two-dimensional, single-phase, isothermal model has been developed for a direct methanol fuel cell (DMFC). The model considers the anode and cathode electrochemical equations, continuity, momentum and species transport in the entire fuel cell. Then, the equations are coupled together and solved simultaneously using a commercial, finite element based, COMSOL Multiphysics software. The crossover of methanol is also investigated in the model. This model describes the electrochemical kinetics of methanol oxidation at the anode catalyst layer by non-Tafel kinetics. The concentration distribution of methanol, water, and oxygen was predicted by the model. In addition, the changes of methanol crossover and fuel utilization with current density were evaluated for different methanol concentrations (0.5 M, 1 M, 2 M, 4 M, and 6 M). Furthermore, it was also found that the crossover of methanol decreases at low methanol concentrations and high current densities. The results show that the polarization curve is in agreement with experimental data.

Keywords

Main Subjects

References

[1] Ismail A., Kamarudin S.K., Daud W.R.W., Masdar S. and Yosfiah M.R., “Review: Mass and heat transport in
direct methanol fuel cells”, J. Power Sources, 2011, 196: 9847.
 
[2] Oliveira V.B., Rangel C.M. and Pinto A.M.F.R., “Water management in direct methanol fuel cells”, Int. J. Hydrogen Energy, 2009, 34: 8245.
 
[3] Wang Z.H. and Wang C.Y., “Mathematical Modeling of Liquid-Feed Direct Methanol Fuel Cells”, J. Electrochemical Society, 2003, 150: A508.
 
[4] Garcia B.L., Sethuraman V.A., Weidner J.W., White R.E. and Dougal R., “Mathematical Model of a Direct Methanol Fuel Cell”, J. Electrochemical Energy Conversion and Storage, 2004, 1: 43.
 
[5] Ge J. and Liu H., “A three-dimensional two-phase flow model for a liquid-fed direct methanol fuel cell”, J. Power Sources, 2007, 163: 907.
 
[6] Yang W.W. and Zhao T.S., “A two-dimensional, two-phase mass transport model for liquid-feed DMFCs”, Electrochimica Acta, 2007, 52: 6125.
 
[7] Colpan CO., Fung A. and Hamdullahpur F., “2D modeling of a flowing-electrolyte direct methanol fuel cell”, J. Power Sources, 2012, 209: 301.
 
[8] Matar S., Ge J. and Liu H., “Modeling the cathode catalyst layer of a Direct Methanol Fuel Cell”, J. Power Sources, 2013, 243: 195.
 
[9] Meyers J.P. and Newman J., “Simulation of the Direct Methanol Fuel Cell - I. Thermodynamic Framework for a Multicomponent Membrane”, J. Electrochemical Society, 2002, 149: A710.
 
[10] Meyers J.P. and Newman J., “Simulation of the direct methanol fuel cell - II. Modeling and data analysis of transport and kinetic Phenomena”, J. Electrochemical Society, 2002, 149: A718.
 
[11] Meyers J.P. and Newman J., “Simulation of the Direct Methanol Fuel Cell - III. Design and Optimization”, J. Electrochemical Society, 2002, 149: A729.
 
[12] Ge J. and Liu H., “Experimental studies of a direct methanol fuel cell”, J. Power Sources, 2005, 142: 56.
 
[13] White F.M., 5th ed., Fluid Mechanics, McGraw-Hill, New York, 2003.
 
[14] Incropera F.D., Fundamentals of Heat and Mass Transfer, John Wiley & Sons, New York, 1995.
 
[15] Shukla A.K., Jackson C.L., Scott K. and Murgia G., “A solid-polymer electrolyte direct methanol fuel cell with a mixed reactant and air anode”, J. Power Sources, 2002, 111: 43.
 
[16] Scott K., Taama W. and Cruickshank J., “Performance and modeling of a direct methanol solid polymer electrolyte fuel cell”, J. Power Sources, 1997, 65: 159.
 
[17] Reid R.C., Prausnitz J.M. and Sherwood T.K., “The properties of gases and liquids”, McGraw-Hill, New York, 1977.
 
[18] Ren X. and Gottesfeld S., “Electro-osmotic drag of water in poly (perfluorosulfonic acid) membranes”, J. Electrochemical Society, 2001, 148, A87.
 
[19] Liu W. and Wang C.Y., “Electron transport in direct methanol fuel cells”, J. Power Sources, 2007, 164: 561.
 
[20] Vera M., “A single-phase model for liquid-feed DMFCs with non-Tafel kinetics”, J. Power Sources, 2007, 171: 763.

Files

Share

How to cite

Statistics